您的位置：首页 > 论文页面
充分供油条件下的润滑状态转变试验观察
发表时间：2018-01-31 浏览量：1822 下载量：337
| 全部作者： | 栗心明，费杨，郭峰，杨萍 |
| 作者单位： | 青岛理工大学机械工程学院 |
| 摘 要： | 利用双色光干涉润滑油膜测量技术，观察充分供油条件下点接触润滑状态的转变过程。结果表明，采用大黏度润滑油，润滑油膜随卷吸速度的增加呈现出从弹流润滑（elastohydrodynamic lubrication，EHL）状态向动压润滑（hydrodynamic lubrication，HL）状态转化的趋势，这两种润滑状态之间存在明显的过渡区间，且该区间受到载荷的影响。随着黏度的降低，润滑油膜偏离理论预测值的临界速度降低，油膜发生润滑状态转化的能力下降。并对不同速度、载荷和黏度条件下润滑状态在不同区间内的转化进行定量分析。 |
| 关 键 词： | 机械学；流体动力润滑；润滑状态；双色光干涉测量 |
| Title： | Experimental investigation of lubrication regime transitions under fully flooded conditions |
| Author： | LI Xinming, FEI Yang, GUO Feng, YANG Ping |
| Organization： | College of Mechanical Engineering, Qingdao University of Technology |
| Abstract： | Using lubrication film measurement technique of dichromatic interferometry, the transition of lubrication regimes were investigated in point contacts under fully flooded conditions. The results showed that, with thick lubricant, the lubrication regime transition from elastohydrodynamic lubrication (EHL) to hydrodynamic lubrication (HL) was obtained by the increasing speed. Moreover, an obvious transition zone was found which was influenced by load. With the lubricant viscosity decreasing, the value of critical speed deviating from the theoretical predications became lower. Moreover, the thinner lubricant compressed the ability of lubrication regime transitions. Finally, lubrication regime transitions in different intervals were quantitatively analyzed with different speeds, loads and viscosities. |
| Key words： | mechanics; hydrodynamic lubrication; lubrication regimes; dichromatic interferometry |
| 发表期数： | 2018年1月第2期 |
| 引用格式： | 栗心明，费杨，郭峰，等. 充分供油条件下的润滑状态转变试验观察[J]. 中国科技论文在线精品论文，2018，11（2）：92-98. |
4
评论数 0请您登录
暂无评论
下载全文
多维论文